Bid 103 Plan Set 41-59 Conformed Plans

Description

1" IF NOT ONE INCH, ADJUST SCALE ACCORDINGLY. BY BAR IS ONE INCH ON OFFICIAL DRAWINGS. 0 CONTINUOUS GASKET BY MECH. CONTRACTOR. OPEN NIPPLE ABOVE TOP OF DRAIN PAN FULL PERIMETER EQUIPMENT CURB. ANCHOR TO STRUCTURE. EXTEND ROOFING MATERIAL UP AND OVER CURB. DRAIN PAN 2" THICK FIBROUS BOARD INSULATION EXISITNG ROOF CONSTRUCTION. GALVANIZED STEEL DUCT CONDENSATE DRAIN TRAP WITH SUFFICIENT TRAP SEAL TO OFFSET PRESSURE AT DRAIN PAN. PITCH DOWN TOWARD DRAIN. MIN. 1/8" PER FT. STRUCTURAL SUPPORT. REFER TO STRUCTURAL DWGS. OVERLAP OUTER JACKET AND SECURE WITH POP RIVETS 16" O.C. T.S.P. OF FAN PLUS 2" WATER DRAIN VAPOR-BARRIER TAPE OVER ALL JOINTS, BREAKS AND PENETRATIONS OF VAPORBARRIER JACKET. "Z" CHANNEL TO SUPPORT JACKETING CORNER BEAD (TYP) ADHESIVE SPOTTED TO ASSIST INSTALLATIONS OF INSULATION BOARD. 3 EXTERIOR DUCT INSULATION DETAIL NOT TO SCALE 2 EQUIPMENT ROOF CURB DETAIL 1 NOT TO SCALE CONDENSATE DRAIN TRAP DETAIL NOT TO SCALE WELD OR SOLDER WATERTIGHT ALL DUCT ABOVE ROOF INSULATION AS REQD 1'-4" MIN CURB FASTENING FLANGE SECURE CURB TO ROOF WITH METHOD CONSISTANT WITH ROOF CONSTRUCTION THERMAL INSULATION ALUMINUM TWIN SHELL CURB 8" MIN ROOF STRUCTURE SEE ARCH AND STRUCTURAL PLANS FOR DETAILS ROOF OPENING AND SIZE PER CURB MFG'S APPROVED SHOP DWGS CONNECT DUCT TO CURB 9/11/2025 10:00:28 AM C:\Users\art01968\Documents\19637.011 Odor Control Improvements - MEP v22_adam.temple5GF4H.rvt 4 ROOF DUCT PENETRATION DETAIL NOT TO SCALE ODOR CONTROL IMPROVEMENTS TOPEKA, KANSAS FASTEN INTO WOODEN OR SIMILAR BASE ROOF DECK W/ BUILT-UP ROOFING; EXTEND TO TOP OF CURB NOTES: 1. SPUD BACK GRAVEL A MIN OF 30" IN ALL DIRECTIONS. FLASH WITH 90# MINERAL FACED BASE FLASHING. STRIP WITH 3 LAYERS OF ROOFING FELT EMBEDDED ASPHALT. GRAVEL TO MATCH 2. INSTALL LOUVER DAMPERS WHEN REQD W/OUT DEFORMATION TO LOUVER FRAME; INSURE LOUVER'S MOVEMENT IS FREE AND UNRESTRICTED AFTER FAN IS INSTALLED ODOR CONTROL IMPROVEMENT MECHANICAL DETAILS ACOUSTICAL LINING DESIGNED BY: BJN DRAWN BY: ART APPROVED BY: WJN DESIGN PROJ: 19637.011 CONST: XXXXX.XXX SCALE: AS NOTED DATE: SEPTEMBER 2025 DRAWING NO: SHEET NO: M-501 42 41 of 53 52 ALL RIGHTS RESERVED.